Product ID:SC-1185, SOLVENT BASED ADHESIVE
MSDS Date:12/24/1988
FSC:8040
NIIN:00-779-9595
MSDS Number: BJYJQ

H.B. FULLER COMPANY

1200 WOLTERS BOULEVARD
VADNAIS HEIGHTS, MN 55110
US

Emergency Phone: 612-481-3300

Info Phone: 612-481-3300

Cage: 9R359

H.B. FULLER COMPANY-FOSTER PRODUCTS DIVISION

ST. PAUL, MN 55126-8076 US

Telephone: 612-236-5300/ -5309 FAX

Cage: 9R359

ACETONE (SARA III)

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: > 10%

OSHA PEL 1000PPM

ACGIH TLV: 750PPM/1000STEL;9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

N-HEPTANE

CAS: 142-82-5

RTECS: MI7700000

Fraction By Weight: > 10%

OSHA PEL 500 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9293

HEXANE (N-HEXANE)

CAS: 110-54-3

RTECS: MN9275000

Fraction By Weight: 1-10%

OSHA PEL 500 PPM

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: > 10%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

651 G VOC/LITER OF MATERIAL, LESS WATER

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:LONG TERM OVEREXPOSURE TO SOLVENTS MAY
CAUSE LIVER AND KIDNEY DAMAGE.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN REGULATED
LEVELS OF NTP, IARC, OR OSHA LISTED CARCINOGENS.
Effects of Overexposure:EYES:CONTACT WILL CAUSE MODERATE
IRRITATION.SKIN:LIQUID CONTACT WILL DRY & DEFAT.REPEATED CONTACT
MAY CAUSE IRRITATION & DERMATITIS.INHALATION:OVEREXPOSURE TO VAPORS
IN POORLY VENTILATED AREAS WILL CA USE IRRITATION OF THE
NOSE,THROAT & RESPIRATORY TRACT & MAY CAUSE
DIZZINESS,HEADACHES,NAUSEA OR UNCONSCIOUSNESS.

First Aid:EYES:FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR 15
MIN. CALL A PHYSICIAN. SKIN:WASH AFFECTED AREA WITH SOAP AND WATER.
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. INHALED:REMOVE FROM
EXPOSURE. RESTORE BREATHING IF NECESSARY. KEEP WARM AND QUIET.
CALL A PHYSICIAN.

Flash Point Method:TCC
Flash Point:< 0F/< -18C
Extinguishing Media:USE WATER SPRAY, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE.
Fire Fighting Procedures:PERSONS EXPOSED TO PRODUCTS OF COMBUSTION
SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE
EQUIPMENT.
Unusual Fire/Explosion Hazard:THERE IS THE POSSIBILITY OF PRESSURE
BUILDUP IN CLOSED CONTAINERS WHEN HEATED. WATER SPRAY MAY BE USED
TO COOL THE CONTAINERS.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. AVOID BREATHING VAPORS. DIKE AND CONTAIN SPILL WITH INERT
ABSORBENT AND TRANSFER TO CONTAINER FOR DISPOSAL. USE NON-SPARKING
TOOLS. KEEP SPILL OUT OF SE WERS.

Handling and Storage Precautions:STORE IN COMPLIANCE WITH OSHA
1910.106. DO NOT STORE NEAR HEAT, SPARKS OR FLAME.AVOID BREATHING
VAPORS.AVOID CONTACT WITH EYES, SKIN & CLOTHING.
Other Precautions:USE W/ADEQUATE VENT.WASH THOROUGHLY AFTER
HANDLING.KEEP CONTAINER CLOSED.EMPTIED CONTAINER RETAINS
VAPOR/PRODUCT RESIDUE.OBSERVE ALL LABEL SAFEGUARDS UNTIL CONTAINER
IS CLEAN.DO NOT CUT/WELD ON/NEAR T HIS CONTAINER.GROUND MAT'L WHEN
POURING

Respiratory Protection:USE NIOSH APPROVED EQUIPMENT, ORGANIC VAPOR
RESPIRATORS WHEN AIRBORNE EXPOSURE LIMITS ARE EXCEEDED.
Ventilation:LOCAL EXHAUST VENTILATION PREFERRED. PROVIDE VENTILATION TO
CONTROL CONTAMINANT LEVELS BELOW AIRBORNE EXPOSURE LIMITS.
Protective Gloves:USE RUBBER GLOVES
Eye Protection:WEAR SAFETY GLASSES,CHEM SAFETY GOGGLES
Other Protective Equipment:APPROPRIATE PROTECTIVE CLOTHING.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health

Boiling Pt:B.P. Text:>133F,>56C
Viscosity:900 CPS
Solubility in Water:NON-MISCIBLE
Appearance and Odor:LIQUID

Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD LOW
MOLECULAR WEIGHT HYDROCARBONS, CARBON MONOXIDE, HYDROGEN CHLORIDE,
PHOSGENE.

Waste Disposal Methods:THIS PRODUCT IS DEFINED AS HAZARDOUS WASTE
IGNITABLE CLASS D001.CONSULT YOUR STATE OR LOCAL AUTHORITY FOR
PROPER DISPOSAL IN THE EVENT MORE RESTRICTIVE REQUIREMENTS
APPLY.FOR ADDITIONAL WASTE DISPOSAL ASSISTANCE CONSULT H.B.FULLER
ENVIRONMENT SERVICE

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.